Size Effect Studies on Concrete Made of Natural and …

Properties of concrete by replacement of natural sand with artificial sand. International Journal of Engineering Research and Technology. 2012 Sep; 1(7): 1-7. …

قرأ أكثر

Concrete Strength Characteristics as a Result of Artificial Sand

A 45 N drop weight was used as the impact load. The number of strikes needed to cause the initial and ultimate failure of concrete samples by dropping a hammer from a height of 457 mm was noted. For the traditional sand concrete, made sand concrete and the best replacement of concrete, tests were carried out and results were presented. IV.

قرأ أكثر

Development of Concrete Using Artificial Sand

— This paper give the experimental study of optimum replacement of natural sand with artificial sand in concrete Concrete may be a combine proportion of cement, sand and mixture. The strength of mixture can have an effect on on the strength of . × ...

قرأ أكثر

IRJET- An Experimantal Investigation of Concrete with Artificial Sand

At replacement of natural sand by artificial sand strengthis5.42%morethanmixwithnatural sand.Asthe % of artificial sand increases shear strength also increases linearly up to 60%. REFERENCES 1. Manasseh Joel, "Use of Crushed Granite Fine as Replacement to River Sand in Concrete Production" Leonardo …

قرأ أكثر

(PDF) Replacement of Natural Sand with Robo/Artificial Sand …

— This paper give the experimental study of optimum replacement of natural sand with artificial sand in concrete Concrete may be a combine proportion of cement, sand and mixture. ... Fellow of Indian Concrete Institute, Chennai Journals of CIVIL ENGINEERING [7]. Dilip K. Kulkarni. INTERNATIONAL JOURNA L OF CIVIL A ND STRUCTURAL …

قرأ أكثر

Comparative Study on performance of concrete with Natural sand …

[3] R. Vinayak Supekar and D. Popat Kumbhar, " Properties of concrete By Replacement Of Natural sand With Artificial sand ", International Journal of Engineering Research & Technology, Vol. 1(7 ...

قرأ أكثر

Making Pump Concrete By Using Artificial Sand

concrete. Bureau of Indian Standards, New Delhi. [4] IS 383-1979 Recommended Guidelines for fine aggregate . Bureau of Indian Standards, New ... Appraisal of Artificial Sand Concrete, IE(I) Journal Volume 90. [10] M.S.Shetty, Concrete Technology- Theory and Practice, (Fifth revised edition, 2002, S.Chand & Company limited, New Delhi). [12]

قرأ أكثر

Strength and Durability of Concrete Manufactured with Artificial Sand

International Research Journal of Engineering and Technology. 3 (7): 954-958. PDF | Annotation: The use of synthetic sand in concrete has attracted the interest of numerous academics all over the ...

قرأ أكثر

Artificial sand making process and application introduction

Raw Material Selection:The artificial sand making process begins with the careful selection of raw materials. Typically, crushed rocks such as granite, basalt, or limestone are chosen for their hardness and durability. These rocks are then fed into crushing machines to produce coarse aggregates. Crushing and Screening:The coarse …

قرأ أكثر

An experimental analysis on the replacement of fine …

Crushing natural stone to produce artificial sand of the right size and quality is the most efficient and cost-effective method for obtaining a substitute for natural sand. ... taking into account several technological, environmental, and economic considerations. In order to conduct tests, concrete mixtures complying with the Indian Standard ...

قرأ أكثر

Experimental Study on Partial Replacement of …

Natural (River) Sand. Natural sand has an excellent modulus of 2.78 and, after washing in clean water, complies with Zone II according to IS: 383-1970. The specific gravity of this …

قرأ أكثر

Study of Suitability of Artificial sand in Plastering & Concrete

Ahn, N. "An Experimental Study on the Guidelines for Using Higher Contents of Aggregate Microfines in Portland Cement Concrete", PhD Dissertation, University of Texas at Austin, 2000. [18] Sahu A.K., Sunil Kumar and Sachan A.K "Quarry Stone Waste as Fine aggregate for concrete", The Indian Concrete Journal, pp. 845-848, 2003.

قرأ أكثر

Properties of Concrete by Replacement of Natural Sand …

In the present an attempt has been made to discuss the properties such as workability and compressive strength of concrete prepared by replacing natural sand with artificial sand at different replacement levels (0%, 20%, 40%, 60% and ). The development of cracks and their measurement is also studied. The results have shown that the natural ...

قرأ أكثر

CONCRETE AS AN ARTIFICIAL ROCK: MINERALOGY OF …

Concrete is a conglomerate of aggregates encapsulated in a. continuous matrix of binder phase. Concrete is comprised of. aggregates more than 70 % by its volume and has a signi cant. in uence on ...

قرأ أكثر

Experimental Study on Compressive Strength of M40 …

Stone Waste as Fine Aggregate for Concrete. The Indian Concrete Journal, vol 77, no 1, p 845. [2] H ... concrete using waste foundry sand", Journal of Chemical and Pharmaceutical Sciences, Vol. 10, Issue 1, PP: 348- 351. ... Strength of M40 Concrete by Replacing Artificial Sand and Steel Fiber against Natural Sand and Cement" Published in

قرأ أكثر

(PDF) Feasibility Of Artificial Sand In Concrete

The replacement of natural sand by artificial sand is feasible for 60% to 80%. It is seen from above studies there is a variation in strength enhancement of concrete made from artificial sand to ...

قرأ أكثر

A review on alternatives to sand replacement and its …

According to the literature review, the maximum substitute rate of sand replacement in concrete may assist to handle a number of disposal-related issues, …

قرأ أكثر

(PDF) INFLUENCE OF ARTIFICIAL SAND ON THE …

The results show that use of Artificial Sand as fine aggregate exhibits 12 – 15% higher flexure strength in comparison to the results of concrete with Natural Sand 47 45.98 46 45 44 43 42 41 41.17 41 40.01 40 39 38 37 …

قرأ أكثر

Studies on strength behaviour of green self cured concrete …

Construction firms now use artificial sand or else manufactured sand in concrete for a day instead of natural river sand, where the excavation prohibition applies to river sand along with the implementation law. ... [10] Nagaraj T. S. and Banu Zahida 1996 Efficient Utilization of Rock Dust and Pebbles as Aggregates in Portland Cement …

قرأ أكثر

A Review on Replacement of Natural Sand with Artificial …

The Indian concrete journal, pp.45-50. [4] Dilip K. Kulkarni. INTERNATINAL JONURAL OF CIVIL AND STRUCTURAL ENGINEERING vol3, no3, ... [11] M R Chitlange 2010, …

قرأ أكثر

Effect of Manufactured Sand on Mechanical Properties of Concrete

This paper present the physibility of artificial sand in concrete for the purpose of experimentation concrete mixes are design for m20 and m25 grades by 0 to 100 % with increment of 20 % replacement of natural sand by artificial sand. Compressive and tensile test are conducted to study the strength of concrete for above replacement.

قرأ أكثر

Development of Concrete Using Artificial Sand

than that of normal sand concrete. REFERENCES [1] A K Sahu, S Kumar and A K Sachin.,2003 Crushed Stone Waste as Fine Aggregate for Concrete.The Indian …

قرأ أكثر

Indian Concrete Journal

Experimental studies on short term mechanical properties of high strength concrete. Indian Concrete Journal, Vol. 90, No. 10, pp. 65-75. ... concrete by replacing natural sand with artificial sand ...

قرأ أكثر

Effect of Artificial Sand on Compressive Strength and …

Keywords: Artificial sand, Concrete, Compressive strength,Workability 1. ... Properties of Concrete By Replacement of Natural Sand With Artificial Sand, International Journal of Engineering Research & Technology (IJERT), Vol. 1 Issue 7, pp 1-7, September 2012. ... (first revision), Bureau of Indian Standards, New Delhi, vii. IS: 516-1959 ...

قرأ أكثر

An experimental analysis on the replacement of fine …

Crushing natural stone to produce artificial sand of the right size and quality is the most efficient and cost-effective method for obtaining a substitute for natural sand. …

قرأ أكثر

Artificial Sand

Reason 3: A lot of construction waste is wasted. Besides, in urban planning and construction, a lot of construction waste is generated. It actually can be crushed by the crushers to produce artificial sand for promoting resource utilization. 3. The development of high-performance concrete technology.

قرأ أكثر

Experimental Analysis on Mechanical Performance of Recycled Concrete …

Soundhirarajan ME and Valli [18] studied the change of concrete strength by replacing natural sand with artificial sand in quarry and believed that artificial sand in quarry was a good substitute. The above studies mainly focus on the working performance and mechanical performance of the RAC, artificial sand concrete, and polypropylene fiber …

قرأ أكثر

Indian Concrete Journal

Technical Papers; Methodology for the repair of beam-column joint Manoj Musale, Akshat Kedar, Gaurang Vashist and M.A. Chakrabarti ; Use of treated domestic effluent as mixing water for concrete: Effect on strength and water penetration at 28 days Devendra Swami, Kaustav Sarkar and Bishwajit Bhattacharjee ; Effect of partial utilisation of lime mud …

قرأ أكثر

Studies on strength behaviour of green self cured …

Construction firms now use artificial sand or else manufactured sand in concrete for a day instead of natural river sand, where the excavation prohibition applies …

قرأ أكثر

Replacement of artificial sand and recycled aggregate …

International Research Journal of Engineering and Technology (IRJET) e-ISSN: 2395-0056 Volume: 03 Issue: 02 | Feb-2016 p-ISSN: 2395-0072 ... Indian Concrete Journal, March 2010. This research ... of tyre rubber as aggregate and artificial sand in concrete contains extensive experimental work.

قرأ أكثر

TECHNICAL PAPER CONCRETE AS AN ARTIFICIAL ROCK …

THE INDIAN CONCRETE JOURNAL | AUGUST 2022 5 CONCRETE AS AN ARTIFICIAL ROCK: MINERALOGY OF ... is captured on a standard thin section of concrete with granite and river sand-based aggregates in ...

قرأ أكثر

Properties Of Concrete By Replacement Of Natural Sand With Artificial …

Shaikh, M. G., Daimi, S. A. (2011), Durability studies of concrete made by using artificial sand with dust and natural sand, International Journal of Earth Sciences and Engineering (ISSN 0974-5904), Vol. 04, No. 06 SPL, pp 823-825. Hudson B.P. (1997), manufactured sand for concrete, The Indian concrete journal (May-1997), pp237-240.

قرأ أكثر

Size Effect Studies on Concrete made of Natural and …

Objective: An experimental investigation was carried out to study the size effect on concrete specimens. Methods: In order to study the size effect compressive and split …

قرأ أكثر

Investigations on physical properties and bulking of …

1.780 g/cc. The average compacted bulk density of natural sand was found to be 1.715 g/cc and that of artificial sand was found to be 1.856 g/cc. The average void ratio of natural sand and artificial sand was. found to be 0.344 and 0.288 respectively. Bulking of artificial sand was higher than natural sand for same.

قرأ أكثر

TO STUDY THE PROPERTIES OF CONCRETE PREPARED USING ARTIFICIAL SAND …

"Strength appraisal of artificial sand as fine aggregate in SFRC." ARPN Journal of Engineering and Applied Sciences 5, no. 10 (2010): 34-38. 3. Shaikh, M. G., and S. A. Daimi. "Durability studies of concrete made by using artificial sand with dust and natural sand." International Journal of Earth Sciences and Engineering 4, no. 06 (2011): 823 ...

قرأ أكثر

Experimental Study on Partial Replacement of Natural …

Natural (River) Sand. Natural sand has an excellent modulus of 2.78 and, after washing in clean water, complies with Zone II according to IS: 383-1970. The specific gravity of this natural sand was found to be 2.55. The water absorption and moisture values obtained for the sand used were 6% and 1.0%, respectively. 3.

قرأ أكثر

Bond Behavior of Reinforced Concrete using Artificial Sand …

It is causing threat to the natural environment. Hence, Indian government has led down restrictions on sand mining from river bed which resulted in the scarcity of natural sand. Now construction industry is looking forward for artificial sand as fine aggregate. Artificial sand is obtained by mechanically crushing the natural rocks.

قرأ أكثر

Indian Concrete Journal

Effect of artificial sand on fresh characteristics of self-compacting geopolymer concrete C. Sashidhar, B. Radhamma, J. Guru Jawahar, ... INDIAN CONCRETE JOURNAL (ICJ) The ICJ is one of the oldest and most respected journals on civil engineering in India. It has served civil engineering community, cementitious building material manufacturers ...

قرأ أكثر

Investigations on concrete with stone crusher dust as

This paper present the physibility of artificial sand in concrete for the purpose of experimentation concrete mixes are design for m20 and m25 grades by 0 to 100 % with increment of 20 % ...

قرأ أكثر

Indian Concrete Journal

An experimental study in developing self-compacting concrete as per IS: 10262 (2019) by utilising the marginal materials as fines Ajay N., Ashwin M. Joshi, Girish S., Namratha Bharadwaj Self-compacting concrete (SCC) is a flowable mix, which can spread and fill the form work completely encapsulating the reinforcement and consolidating on its own self …

قرأ أكثر